Welcome to the Rx7 Forum and Owners Club.
If this is your first visit, be sure to check out the FAQ by clicking the link above. You may have to register before you can post: click the register link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below.

<<<<<< Register to remove these ads >>>>>>


Go Back   Rx7 Forum and Owners Club > General RX-7 Area > FAQ

FAQ If you have any questions about engine work, parts needed, part locations, anything....post it all here in the FAQ section!


Reply
 
Thread Tools Display Modes
Old 02-27-2005, 04:20 AM   #1
dRuNk-mEdIc
Full Access Member
 
Join Date: Feb 2005
Location: Cali 949
Posts: 73
Send a message via AIM to dRuNk-mEdIc
Default Terms we use in Mazda RX7 form
Some vocab for you noob's

ABS - Anti-lock Brake System - prevents skidding and enhances car control during braking; the 3rd gen RX-7 has a 3 channel (two front, one rear) system
AIR PUMP - Pumps air into the exhaust and main catalytic converter to reduce pollution
ANTIROLL BAR (Sway Bar, Stabilizer Bar) - Suspension piece that limits the amount of body roll while cornering
ASP - A Street Prepared, SCCA racing class for highly modified cars
AST - Air Separation Tank - removes bubbles from coolant, often cracks and leaks, see the Coolant Tank Elimination how-to to get rid of it
ATDC - BTDC - After (Before) Top Dead Center, term used for adjusting ignition timing
BLOW-OFF VALVE - valve that bleeds off excessive boost pressure when the throttle is closed (like between shifts) by dumping air from the intake
BOOST - Intake pressure created by the turbocharger - given in pounds per square inch (PSI) or bar (metric), see the Manual Boost Controller how-to to adjust boost
BOOST CREEP - Slow rise of max boost at high rpm - caused by inadequate size of the wastegate
BOOST SPIKE - Sudden rise in turbo boost pressure, caused by second turbo coming online around 4500 rpm in modified 3rd gen RX-7's, see the Manual Boost Controller how-to for a way to reduce spiking
CFDF - Center Force Dual Friction clutch, recommended by the mail list but seems inadequate for drag racing
CRANE HI-6 - Ignition amplifier, increases strength of ignition spark, only needed when running higher than stock boost
CYM - Rare RX-7 exterior color, Competition Yellow Mica
ECU - Electronic Control Unit - the computer brain that controls the engine
EFINI - Japanese name for the 3rd gen RX-7
EGR - Exhaust Gas Recirculation valve - pollution control device that injects a small amount of exhaust gas into the intake stream to decrease combustion temperature and nitrous oxides
EVC - Electronic Valve Controller - Computer controlled boost controller (controls the wastegate)
EXHAUST SYSTEM (3 SECTIONS):
* PRE-CAT - Pre-catalytic converter - the first part of the exhaust - decreases pollution at start up
* CAT - Main catalytic converter - the middle section of the exhaust
* CAT-BACK - The last section of the exhaust (from the CATalytic converter BACK) - usually includes a muffler
* DOWN PIPE - Replaces the Pre-Cat for better exhaust flow
* MID PIPE - Replaces the main catalytic converter for better exhaust flow
FCD - Fuel Cut Defenser - prevents the ECU from cutting fuel to the rear rotor when boost pressure exceeds approximately 11-13 psi, should only be used with GReddy FCON because it tells the ECU boost is lower than actual
FC3S - Another term for second generation RX-7 (1986 - 1991)
FD3S - Another term for third generation RX-7 (1993 - now)
FCON - Fuel CONtroller - Piggyback fuel controller that prevents a modified engine from running lean by fooling the ECU into supplying more fuel to the engine when at full throttle
GReddy - After-market performance parts manufacturer
HKS - After-market performance parts manufacturer
INTERCOOLER - (IC) A radiator-like device that hot, compressed air from the turbo flows through for cooling - increases horsepower and lowers risk of detonation
KOKO - Key On, Key Off - can temporarily cure some boost problems, it does a soft reset of the ECU
LSD - Limited Slip Differential - sends torque to the wheel that is spinning the least - all 3rd generation RX-7's have them
MAP - Manifold Absolute Pressure sensor (manifold pressure)
MM - Mostly Mazda, after-market parts maker and repair shop
N/A - Normally Aspirated (non-turbo), all 3rd gen RX-7's are turbocharged
NOS - Nitrous Oxide System - Nitrogen Oxide gas (and usually additional fuel) is injected into the intake to increase power
O2 SENSOR - OXYGEN SENSOR - tells the ECU how much oxygen is present in the exhaust, more O2 = lean mixture, less = rich (not used during wide open throttle)
OEM - (OE) Original Equipment Manufacturer
PEG - (PEP in 95) Popular Equipment Group (Package) - Sunroof, Rear Cargo Cover, Leather. In 1995, fog lights were added to PEG. Reading from the 1994 window sticker: 1PE POPULAR EQUIPMENT GROUP $1800
PFS - Peter Farrell Supercars - After-market performance parts manufacturer
PIGGYBACK ENGINE CONTROLLER - A non-stand-alone engine/fuel computer that works with the stock ECU such as the EFI PMS. The Motec and Wolf 3D computers are stand-alone--they eliminate the stock ECU
PMC - Powertrain Management Computer (PFS Purple Computer) - Piggyback engine control computer that controls boost, timing, and fuel, very programmable; sold by PFS, made by EFI
PMS - Programable Management System by EFI Systems - piggyback engine control computer that controls boost, timing, and fuel, very programmable, same unit as the PFS PMC
PROFEC - GReddy boost controller - electronically controls the wastegate to control boost, uses "fuzzy logic" to learn your car's boost pattern
PROFEC B - Similar to PROFEC but less programming and no "fuzzy logic"
R1 (93), R2 (94,95) - Sport tuned suspension version of the 3rd generation RX-7
RB - Racing Beat - High quality Japanese parts supplier
REBIC III - Used to control additional fuel injectors - GReddy
REBIC SIM - Allows more control of REBIC III - GReddy
SCCA - Sports Car Club of America
SS - Stainless Steel
SST - Special Service Tool, term used in the RX-7 Workshop Manual
SWAY BAR - See Antiroll Bar
TOURING - Equipment option (leather interior, sunroof, Bose sound, etc.)
TPS - Throttle Position Sensor
VR - RX-7 exterior color, Vintage Red
WASTEGATE - Valve that controls turbo boost pressure by allowing exhaust to bypass the turbo
WFO - WOT - Wide F'ing Open, Wide Open Throttle
Y-PIPE - Air pipe that collects air from the two turbochargers and connects to the plastic crossover tube (which often cracks at both ends). The Efini Y-pipe comes with a metal crossover tube and eliminates the unreliable rubber coupler between the Y-pipe and crossover tube.


__________________
D1.....yep.yep.....crazy ass shit

You can put 20 grand into your honda and its still a honda.

My RX7.....well its an RX7.
dRuNk-mEdIc is offline   Reply With Quote
Old 05-30-2012, 12:59 PM   #2
 
BoostedFC's Avatar
BoostedFC
Moderator
 
Join Date: Sep 2010
Location: Fredericksburg, Va
Age: 38
Posts: 785
Default
Some more that might be seen.

FMIC = front mount intercooler
SMIC = side mount intercooler
Vmount = intercooler is mounted in a v formation with the radiator
Test pipe = cat delete or straight pipe
SA22C = 1978-1980 series 1 RX7
FB3S = 1981-1985 series 2 & 3 RX7
BOV = blow off valve, a valve take vents air into the atmosphere when the the throttle plate is closed preventing air flowing back.
Bypass valve =recirulated valve similar to a BOV, but vents back into the intake stream
BBK = big brake kit
W/I = water injection
Camber = the vertical angle of the tires
Caster = longitudinal angle of the tires
Toe = direction in which the tires are pointing
ATF = automatic transmission fluid
CAI = cold air intake
SRI = short ram intake
CAS = crank angle sensor


__________________
Supercharged or Turbocharged, Boost is Boost
Big Body on 335's!!!!!

Last edited by BoostedFC; 06-05-2012 at 03:24 AM.
BoostedFC is offline   Reply With Quote
Old 01-14-2018, 09:59 PM   #3
Crocci
Junior Member
 
Join Date: Jan 2018
Posts: 6
Default
Thanks for useful information. Glad to join to your community
__________________________________________________
192.168.1.1
Crocci is offline   Reply With Quote
Reply


Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
 
Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump